File(s) not publicly available

Effect of antioxidant on the performance and emission characteristics of a diesel engine fueled with palm biodiesel blends

journal contribution
posted on 07.08.2018, 00:00 by IM Rizwanul Fattah, HH Masjuki, MA Kalam, M Mofijur, MJ Abedin
Biodiesel is a clean-burning alternative fuel produced from renewable resources. However, it is susceptible to oxidative degradation due to autoxidation in the presence of oxygen, which hinders its widespread use. Antioxidant addition is a prospective solution to this problem. It is expected that antioxidants may affect the clean-burning characteristic of biodiesel. Palm biodiesel (PME) is the most used biodiesel in Malaysia. This paper presents an experimental investigation of the effect of antioxidant addition to palm biodiesel on engine performance and emission characteristics. PME was produced by transesterification using potassium hydroxide (KOH) as catalyst. Two monophenolic antioxidants, 2,6-di-tert-butyl-4-methylphenol (BHA) and 2(3)-tert-butyl-4-methoxy phenol (BHT), were added at 1000 ppm concentration to 20% PME (B20) to study their effect. The addition of antioxidants increased oxidation stability without causing any significant negative effect on physicochemical properties. BHA showed greater capability to increase the stability of B20. A 42-kW, 1.8-L, four-cylinder diesel engine was used to carry out tests under conditions of constant load and varying speed. The results show that B20 and antioxidant-treated B20 produced 0.68-1.02% lower brake power (BP) and 4.03-4.71% higher brake specific fuel consumption (BSFC) compared to diesel. Both of the antioxidants reduced NOx by a mean of 9.8-12.6% compared to B20. However, compared to B20, mean increases in carbon monoxide (CO) and hydrocarbon (HC) emissions of 8.6-12.3% and 9.1-12.0%, respectively, were observed. The emission levels of the three pollutants were lower than those of diesel. Thus, B20 blends with added antioxidant can be used in diesel engines without any modifications. © 2013 Elsevier Ltd. All rights reserved.

Funding

Other

History

Volume

79

Start Page

265

End Page

272

Number of Pages

8

ISSN

0196-8904

Publisher

Elsevier, UK

Peer Reviewed

Yes

Open Access

No

Acceptance Date

10/12/2013

External Author Affiliations

University of Malaya, Malaysia

Era Eligible

Yes

Journal

Energy Conversion and Management